Safety Standards

OSHA Fall Protection (29 CFR 1926.501)

Roofing is OSHA's highest-risk construction trade for fatal falls. Federal regulation requires conventional fall protection at any work height of 6 feet or more above a lower level. AC INC Roofing meets or exceeds the standard on every roof — no exceptions for steep pitches, cold weather, or "quick" repairs.

• Personal Fall Arrest Systems (PFAS): full-body harness, shock-absorbing lanyard, properly anchored rope grab on every crew member above 6 ft
• Roof anchor points installed and inspected before crews go up — not improvised mid-job
• Roof brackets + walk boards on pitches above 6:12 for material handling
• Guardrail systems on commercial low-slope perimeters where conventional protection is feasible
• Site-specific fall protection plan filed for any roof where conventional methods are infeasible (per 1926.502(k))

Worker Training & Equipment

Crews receive documented OSHA 10-hour or 30-hour training, manufacturer install certifications (GAF, Owens Corning, CertainTeed, Carlisle), and weekly toolbox safety briefings on the day's specific hazards. Harnesses are inspected pre-shift and rotated out at manufacturer-recommended intervals. Ladders are tied off at the top — not just leaned.

Property & Public Safety

Safety isn't only about the crew. We protect everything below the roof line throughout the job:

• Tarps over landscaping, AC condensers, and outdoor furniture before tear-off begins
• Plywood protection over driveway / sidewalk where dumpster placement requires it
• Magnetic nail sweep on driveway, walkways, and lawn at the end of every work day
• Drive-by perimeter check before crews leave site
• No power tools or work activity above pedestrians or pets — we coordinate with you

Storm Emergency & Temporary Mitigation

When a storm opens a roof or a tree falls, life safety and stopping water intrusion come first. Our emergency mitigation crews carry tarps, plywood, and synthetic underlayment to weatherize an opening within hours of dispatch. We document the original damage with photos and timestamps before tarping so insurance scope is preserved.

• Emergency mitigation dispatched 24/7 during active storm seasons
• Photo + timestamp documentation before any temporary repair
• Reasonable mitigation cost is typically reimbursable under most homeowners policies (see Insurance Claim Support)
• Temporary fixes are clearly invoiced separately from permanent restoration

Installation Standards

Every install follows the manufacturer's published specification — not field-shortcut versions of it. That matters because manufacturer warranties hinge on install fidelity: skip the starter strip, undersize the ventilation, or use the wrong-pattern nailing and the warranty gets contested at the worst possible moment (during a future leak).

• Nailing pattern verified to match shingle line spec (4-nail vs. 6-nail high-wind)
• Balanced ridge-and-soffit ventilation calculated to NFA tables
• Ice & water shield at eaves, valleys, penetrations, and any low-slope transitions
• Synthetic underlayment over the field, mechanically attached
• Step flashing on every wall transition, kick-out flashing at wall-to-roof terminations
• Pipe boots, attic vents, and accessories replaced new — not reused

Frequently Asked Questions

What insurance do you carry?

AC INC Roofing carries general liability and workers' compensation insurance well above industry-standard minimums (most manufacturer programs require $1M GL minimum; we exceed that). Certificates of insurance can be issued naming your property and lender on request before work begins.

Are your subcontractors insured?

Yes. Every crew that sets foot on a roof under our name carries documented workers' comp and general liability coverage. We don't accept "owner-operator" subs without certificates on file. The point of asking that question is to make sure injuries on your property don't become your liability — they don't.

How do you handle pets and kids during a roof tear-off?

We coordinate with you on timing and access. Tear-off is loud (think jackhammer-level), debris-heavy, and unsafe for anyone walking the perimeter. We recommend keeping pets indoors or off-site for the tear-off + dry-in day, and we set up a clear safe-walk path to the front door for normal household movement.